HVAC Installation & Replacement in Canton, Michigan

The subdivisions and older blocks of Canton are full of systems that went in all at once and are reaching the end all at once. Builder-grade furnaces and condensers installed in the 1980s–2010s subdivision colonials and ranches around Fellows Creek tend to fail within a few years of each other, which is why HVAC installation in Canton is a steady part of our work. What we do differently than the larger outfits in Wayne County is simple: no sales team, no same-day-only pricing, a load calculation instead of a nameplate match, and the owner on the install. A new system in 48187 from Temprasure is sized for the house, permitted, inspected and commissioned, and it comes with a free estimate that you can sit on as long as you want.

Canton houses and what that means for hvac installation

Canton is the most uniform housing stock in our radius, and that makes the failure patterns predictable. The bulk of the township is 1985 to 2010 colonials and split-levels on poured concrete basements, with a builder-grade 80 percent furnace in a corner of the basement and a two-and-a-half or three-ton condenser on a pad by the side door. Many of those original furnaces have already been replaced once, often with a 90-plus condensing unit vented in PVC out the rim joist, and a good share of the condensers are first-generation R-410A units from the mid-2000s. The oldest pockets, like Pheasant Run and Windridge, are late 1970s and early 1980s ranches and quad-levels, and the quad-levels in particular have a lower-level family room that never gets enough supply air. Cherry Hill Village homes from the 2000s are tighter and often have two-zone systems or a second furnace in the attic. Finished basements are the norm, so equipment ends up boxed into utility rooms sized for the original furnace, not the replacement.

Venting is the second thing we look at hard in Canton. A high-efficiency condensing furnace vents through the side wall in PVC, which frees up the masonry chimney that an older 80% furnace shared with the water heater. In the 1980s–2010s subdivision colonials and ranches common near Canton Center Road's Preservation Park, that leaves a 40-gallon atmospheric water heater alone on a chimney that is now too large for it, and the flue gases can condense and eat the liner. We address that on the estimate, either with a chimney liner sized for the water heater or by talking through a power-vent water heater at the same time. Canton homes on DTE Energy gas also get the gas line pressure-tested and the drip leg and shutoff brought up to current code as part of the install.

With about 99,000, one of the largest townships in Michigan residents and housing that runs from the 1980s–2010s subdivision colonials and ranches around Windridge Village to the newer streets near Lilley Road corridor, Canton keeps us busy year-round. The equipment is on DTE Energy for heat and DTE Energy for cooling, the basements near Heritage Park are prone to the same moisture issues as the rest of Wayne County, and the ductwork in a lot of these houses was never sized for the air conditioner that was bolted on later. We are 10 miles away, we service every brand, and we quote a flat rate before we start.

Local details we plan around in Canton

• Canton Township's building department requires a mechanical permit and a final inspection for furnace, air conditioner and water heater replacements, and they do enforce it.
• Two-story colonials with a single system here almost always have upstairs bedrooms running five to eight degrees warmer in summer, a duct-balancing and return-air problem more than an equipment problem.
• Township water is Detroit-system water through the Great Lakes Water Authority, softer than Ypsilanti's, so water heater sediment is less of an issue than in Washtenaw County.
• Canton is flat and open, with little tree cover in the newer subdivisions, so summer sun hits west-facing second floors hard and January wind drives infiltration across the open ground south of Palmer Road. The Lower Rouge and Fellows Creek run through the middle of the township, and basements near those drains and the Tonquish Creek corridor carry more moisture. Dew points in July sit in the upper 60s, which makes a properly sized condenser matter more than raw tonnage.